Acer Veriton 5500 Technical Information

Veriton 3500/5500/7500Service Guide PART NO.:

Chapter 1 1OverviewThe Veriton 3500, 5500, 7500 supports Intel® Pentium IV (Willamette 478/Northwood) Flip Chip-Pin Grid Array 2 processor (FC-PGA2) b

Chapter 3 92Removing the Hard Diskette Drive and Floppy Diskette Drive1.See “Removing the Housing Cover” on page 862.See “Removing a Dummy Link Bar” o

93 Veriton 3500/5500/75008.Remove the four screws as shown here and then detach the floppy disk drive module from the link bar.Removing the CD-RW &

Chapter 3 948.Remove the two screws that hold the DVD-RW driver to the bracket frame.9.Disconnect the DVD-ROM power cable, DVD-ROM IDE cable, and audi

95 Veriton 3500/5500/7500Removing the Power Supply1.See “Removing the Housing Cover” on page 862.See “Removing a Dummy Link Bar” on page 873.See “Remo

Chapter 3 963.Disconnect the power LED, hard disk drive activity LED and network activity cables from the main board. Removing Power Switch Cable1.See

97 Veriton 3500/5500/7500Removing the System Main Board1.See “Removing the Housing Cover” on page 862.See “Removing a Dummy Link Bar” on page 873.See

Chapter 3 98Veriton 7500/ 7500G Disassembly Procedure FlowchartThe flowchart on the succeeding page gives you a graphical representation on the entire

99 Veriton 3500/5500/7500Disassembling the Veriton 7500/ 7500GOpening the HousingThis section tells you how to open the housing cover when you need to

Chapter 3 100Removing the Modem Card1.See “Removing the Housing” on page 99. (Remove the left panel only)2.Remove the screw on the bracket of the mod

101 Veriton 3500/5500/7500Removing the USB/ Audio Board1.See “Removing the Housing” on page 992.See “Removing the Front Panel” on page 993.See “Removi

2 Veriton 3500/5500/7500Features Performance! Intel Pentium® IV processor with Intel NetBurst™ micro-architecture and integrated 256KB/512KB embed

Chapter 3 102Removing the DVD-ROM and CD-RW Drive 1.See “Removing the Housing” on page 99. 2.See “Removing the Front Panel” on page 993.Disconnect th

103 Veriton 3500/5500/75006.Remove the four screws holding DVD-ROM to the housing.7.Disconnect the DVD-ROM power cable, DVD-ROM IDE cable, and audio c

Chapter 3 1043.Disconnect the floppy disk drive cable and the floppy disk drive power connector, then remove the diskette drive from the housing.Remov

105 Veriton 3500/5500/7500Removing a DIMM1.See “Removing the Housing” on page 99. (Remove the left panel only)2.Press the levers on both sides of the

Chapter 3 106Removing and Installing the Processor1.See “Removing the Housing” on page 99. (Remove the left panel only)2.See “Removing the CPU Fan Si

107 Veriton 3500/5500/7500Removing the Power Supply1.See “Removing the Housing” on page 99. (Remove the left panel only)2.Disconnect the FDD power co

Chapter 3 108Removing the Main Board 1.See “Removing the Housing” on page 99. (Remove the left panel only)2.Put the housing to lying position with t

109 Veriton 3500/5500/7500

Chapter 4 110This chapter provides troubleshooting information for the Veriton 3500/5500/7500, and the Veriton 3500G/5500G/7500G! Power-On Self-Test (

111 Veriton 3500/5500/7500Power-On Self-Test (POST)Each time you turn on the system, the Power-on Self Test (POST) is initiated. Several items are tes

Chapter 1 3! High-speed 56K V9.0 fax/data/voice PCI modem (optional)! One RJ45 connector supports IEEE 802.3./802.3u 10Base-T/100Base-TX-compatible ne

Chapter 4 11204h Reserved05h 1. Blank out screen2. Clear CMOS error flag06h Reserved07h 1. Clear 8042 interfac2. Initialize 8042 self-test08h 1. Test

113 Veriton 3500/5500/750023h 1. Check validity of RTC value: e.g. a value of 5Ah is an invalid value for RTC minute.2. Load CMOS settings into BIO

Chapter 4 11443h Test 8259 functionality44h Reserved45h Reserved46h Reserved47h Initialize EISA slot48h Reserved49h 1. Calculate total memory by testi

115 Veriton 3500/5500/750067h Prepare memory size information for function call:INT 15h ax=E820h68h Reserved69h Turn on L2 cach6Ah Reserved6Bh Program

Chapter 4 11685h 1. USB final Initialization2. NET PC: Build SYSID structure3. Switch screen back to text mode.4. Set up ACPI table at top of memory.5

117 Veriton 3500/5500/7500POST Error Messages ListIf you cannot run the diagnostics program tests but did receive a POST error message, use “POST Erro

Chapter 4 118Memory Test: This message displays during a full memory test, counting down the memory areas being tested.Memory test fail If POST detect

119 Veriton 3500/5500/7500Error Symptoms ListNOTE: To diagnose a problem, first find the error symptom in the left column. If directed to a check proc

Chapter 4 120Diskette drive LED comes on for more than 2 minutes when reading data.1. Diskette2. Diskette drive connection/cable 3. Diskette drive4

121 Veriton 3500/5500/7500AudioAudio software program invokes but no sound comes from speakers.1. Speaker power/connection/cable.ModemModem ring cann

4 Veriton 3500/5500/7500Front Panel-Veriton 3500/3500G The computer’s front panel consists of the following: Label Icon Description1 Floppy drive ligh

Chapter 4 122Parallel/Serial PortsExecute “Load BIOS Default Settings” in BIOS Setup to confirm ports presence before diagnosing any parallel/serial p

123 Veriton 3500/5500/7500Undetermined ProblemsIf an error message is present, go to “POST Error Messages List” on page 117. If you did not receive an

Chapter 5 124Jumpers and ConnectorsRefer to the following figure for the location of the jumpers and connectors on the main board:Jumper and Connector

125 Veriton 3500/5500/7500Main board (3500/ 5500/ 7500)(S88M/GL)CN2 CN3 CN8 CN10 CN14CN18CN6CN11CN4CN7DIMM 2DIMM 1FN1U8FN2U14CN16CN17CN21CN25CN19JP2CN

Chapter 5 126Main board (3500G/ 5500G/ 7500G)(S88M/G)CN2 CN3 CN8 CN10 CN14CN18CN6CN11CN4CN7DIMM 2DIMM 1FN1U8FN2U14SLT1CN16CN17CN21CN25CN19JP2CN20CN22C

127 Veriton 3500/5500/7500Connector Description NOTE: There is no AGP VGA slot for S88M/GL.NOTE: *: Intel 845 GL (Veriton 3500/ 5500/ 7500); Intel 845

Chapter 6 128This chapter gives you the FRU (Field Replaceable Unit) listing in global configurations of Veriton 3500/ 3500G, 5500/ 5500G, 7500/ 7500

129 Veriton 3500/5500/7500Veriton 3500/ 3500G Exploded DiagramPicture No. Part Name DescriptionFloppy Disk Drive3 FDD 1.44M MITSUMI/D353M3D FDD 1.4

Chapter 6 130NS RTC BATTERY LI 3V 200MAH BATTERY LI 3V CR2032 200MAH CableNS IDE CABLE 40PIN 2C 300M C.A.40P 2C 300MM HDD H348 FDD CABLE 34/34PIN 28

131 Veriton 3500/5500/75001-8 MICRO SWITCH CABLE 2PIN 500MM H34C.A.2P MICRO SW 500MM H34 NS AUDIO CABLE 4PIN 2CONNECTOR 520MW.A 4P 2C AUDIO 520M

Chapter 1 5NOTE: *The system has two microphone-in ports (front and rear). However, you cannot use both of them at the same time. The default setting

Chapter 6 132BoardNS AUDIO/USB BOARD S88M DAUGHTER BOARD Power SupplyNS POWER SUPPLY 160W AOPEN FSP160-60SAV V.1SPS 160WNOPFC FSP160-60SAV V.1

133 Veriton 3500/5500/75001-5 I/O PPORT BRACKET W/ LABEL ASSY. I/O BRACKETMiscellaneous7 FOOT STAND ASSY FOOT STAND ABS 501 H34 NS I/O PORT LABEL Lab

Chapter 6 134NS SCREW SCRW TAP PAN M3*8L 2LEAD Picture No. Part Name Description

135 Veriton 3500/5500/7500Veriton 5500/ 5500G Exploded DiagramPicture No. Part Name DescriptionFloppy Disk Drive8 FDD 1.44M MITSUMI/D353M3D FDD 1.4

Chapter 6 136NS RTC BATTERY LI 3V 200MAH BATTERY LI 3V CR2032 200MAH CableNS IDE CABLE 40PIN 3CONNECTOR 150+300MC.A 40P 3C 150+300MM IDE H61 9 FD

137 Veriton 3500/5500/75001-13 INTRUSION ALERT MICRO SWITCH CABLE ASSY MICRO/SW CABLE H4VT51001-12 LED CABLE MODULE TURBO/HDD/POWERASSEMBLY LED CABLE

Chapter 6 138Power Supply3 POWER SUPPLY 200W DELTA DPS-200PB-112A 01SPS 200W PFC DPS-200PB-112A 01 Case/Cover/Bracket Assembly1-9 UPPER CASE ASSY UPP

139 Veriton 3500/5500/7500NS I/O PORT BRACKET W/O LABEL ASSY PORT BRACKET(S88M) H80 MiscellaneousNS NAME PLATE VT550 LBL NAME PLT49.6*9.6VT5500 H4

Chapter 6 14041-14SCREW SCREW TAP HEX ZNIC #6-32*4/16" 1-15 SCREW SCRW MACH FLAT M3*0.5P*8L NI Picture No. Part Name Description

141 Veriton 3500/5500/7500Veriton 7500/ 7500G Exploded DiagramPicture No. Part Name DescriptionFloppy Disk Drive2 FDD 1.44M MITSUMI/D353M3D FDD 1.4

6 Veriton 3500/5500/7500Rear Panel-Veriton 3500/3500GLabel Icon Color Description1Power supply2 Voltage selector switch3Keyhol4GreenPS/2 mouse port 5

Chapter 6 142NS RTC BATTERY 3V 200MAH BATTERY LI 3V CR2032 200MAH CableNS IDE CABLE 40PIN 3CONNECTOR 150+300MC.A 40P 3C 150+300MM IDE H61 4 FDD C

143 Veriton 3500/5500/75001-15 INTRUSION ALERT MICRO SWITCH CABLE 2PIN 500MM W.A. 2P ALARM SW 500MM CABLE 2 1-8 LED CABLE MODULE POWER LED/TURBO LED

Chapter 6 144Power SupplyNS POWER SUPPLY 200W DELTA DPS-200PB-112B 01SPS 200W PFC DPS-200PB-112B 01 Case/Cover/Bracket Assembly1-1 RIGHT DOOR CVR R

145 Veriton 3500/5500/7500NS NAME PLATE VT750 LBL NAME PLT49.6*9.6VT7500 H80NS RUBBER FOOT RUBBER FOOT T-6.8 IDBNS I/O PORT LABEL LBL I/O Port 40.7x15

Chapter 6 14691-18SCREW SCRW TAP HEX ZINC M3*.5*5 81-9SCREW SCREW TAP HEX ZNIC #6-32*4/16" Picture No. Part Name Description

Appendix A 147Veriton 3500/5500/75001. Brand No: S88M/ GL MB2. Project Name/ Code: S88M / 91.31V01.301(Veriton 3500)

148 Veriton 3500/5500/7500Veriton 3500G/5500G/7500G1. Brand No: S88M/ G MB2. Project Name/ Code: S88M 91.31V01.301(Veriton 3500G)

Appendix A 149Main Features ! Single Intel Pentium 4/ Northwood processor configurations at 400/ 533MHz for S88M/ G and at 400MHz for S88M/ GL.! AGT

Appendix B 150This computer’s compatibility is a test plan released by Acer Internal Testing Department. Once the final report is available, this chap

151 Veriton 3500/5500/7500Microsoft Windows XP Professional Environment Test Item SpecificationsProcessor Intel Willamette 1.7G/1.8G/1.9G/2.0 Socket 4

Chapter 1 7NOTE: * The CRT monitor port is automatically disabled when an add-on AGP VGA card is installed into the system. Connect the monitor to the

Appendix B 152VGA Adapter LEADTEK Geforce 2 MX-400 64M LPProlink Geforce 2 MX-400 64M LPECS SiS 315EECS SiS 315E LBSpeake Charming Standard V-1Charmin

153 Veriton 3500/5500/7500Microsoft Windows ME Professional Environment Test Item SpecificationProcessor Intel Willamette 1.7G/1.8G/1.9G/2.0 Socket 4

Appendix B 154Speake Charming Standard V-1Charming Speake 2.1 channelLAN Adapter 3Com LAN Card, 10/100 MbpsLAN card, 10/100 Mbps LBFax/Modem Adapter A

155 Veriton 3500/5500/7500Microsoft Windows 2000 Professional Environment Test Item SpecificationsProcessor Intel Willamette 1.7G/1.8G/1.9G/2.0 Socket

Appendix B 156Speake Charming Standard V-1Charming Speake 2.1 channelLAN Adapter 3Com LAN Card, 10/100 MbpsLAN card, 10/100 Mbps LBFax/Modem Adapter A

157 Veriton 3500/5500/7500Linux Red Hat Environment TestItem SpecificationsProcessor Intel Willamette 1.7G/1.8G/1.9G/2.0 Socket 478Intel Northwood 2.0

Appendix B 158Speake Charming Standard V-1Charming Speake 2.1 channelLAN Adapter 3Com LAN Card, 10/100 MbpsLAN card, 10/100 Mbps LBFax/Modem Adapter A

159 Veriton 3500/5500/7500

Appendix C 160This section describes online technical support services available to help you repair your Acer Systems.If you are a distributor, dealer

161 Veriton 3500/5500/7500

8 Veriton 3500/5500/7500Front Panel-Veriron 5500/5500G The computer’s front panel consists of the following:Label Icon Description1 Hard disk drive ac

Index 162AAssignment Map 30Audiocontroller 26Audio Interface 26Audio-in/Line-in port 11, 15Audio-out/Line-out port 11, 15BBasic level 37BIOS Setup 36E

163 IndexIDSEL 30Interfaceaudio 26IDE 26Video 25IRQ Assignment Map 31JJumper and Connector Information 124Jumpers 124Kkeyboard 21LLinux Red Hat Enviro

Index 164Audio 121CD/DVD-ROM Drive 120Diskette Drive 119Keyboard 122Memory 119Modem 121Monitor 121Other 122Parallel Port 122Power Supply 122Processor

165 Index

Chapter 1 9NOTE: * The system has two microphone-in ports (front and rear). However, you can not use both of them at the same time. The default setti

10 Veriton 3500/5500/7500Rear Panel-Veriton 5500/5500GLabel Icon Color escription1 Voltage selector switch2 Green PS/2 mouse port3 Power jack (for ext

IIRevision HistoryPlease refer to the table below for the updates made on Veriton 3500/5500/7500 service guide.Date Chapter Updates

Chapter 1 11NOTE: * The CRT monitor port is automatically disabled when an add-on AGP VGA card is installed into the system. Connect the monitor to t

12 Veriton 3500/5500/7500Front Panel-Veriton 7500/7500G The computer’s front panel consists of the following:Label Icon Description1 CD-ROM/DVD-ROM tr

Chapter 1 13NOTE: * The system has two microphone-in ports (front and rear). However, you can not use both of them at the same time. The default sett

14 Veriton 3500/5500/7500Rear Panel-Veriton 7500/7500GLabel Icon Color Description1 Voltage Selector Switch2 Power cord socket3 Burgundy Parallel/prin

Chapter 1 15NOTE: * The CRT monitor port is automatically disabled when an add-on AGP VGA card is installed into the system. Connect the monitor to th

16 Veriton 3500/5500/7500System Block Diagram (Veriton 3500/ 5500/ 7500)Willamette/Northwood ProcessorBrookdale-GLGMCHICH46 USB 2.0ports2 ATA 100 IDEC

Chapter 1 17System Block Diagram (Veriton 3500G/ 5500G/ 7500G)Willamette/Northwood ProcessorBrookdale-GGMCHICH4AGP6 USB 2.0ports2 ATA 100 IDEChannelsL

18 Veriton 3500/5500/7500Main Board Layout (Veriton 3500/ 5500/ 7500) (S88M/ GL)30 292827261713635343332311891314151619202123456781011122223253738

Chapter 1 19Main Board Layout (Veriton 3500G/5500G/7500G) (S88M/ G)30 29282726171363534333231189131415161920212345678101112222324253738

20 Veriton 3500/5500/7500NOTE: *: default settingNOTE: **: Intel 845 GL (Veriton 3500/ 5500/ 7500); Intel 845G (Veriton 3500G/ 5500G/ 7500G)NOTE: ***:

IIICopyrightCopyright © 2002 by Acer Incorporated. All rights reserved. No part of this publication may be reproduced, transmitted, transcribed, sto

Chapter 1 21Keyboard (3500/ 3500G, 5500/ 5500G, 7500/ 7500G)The keyboard has full-sized keys that include separate cursor keys, two Windows keys, and

22 Veriton 3500/5500/75009Volume control/Mute knob Controls the speaker volume. Turn it clockwise or counterclockwise to adjust the volume. Press it t

Chapter 1 23Hardware Specifications and ConfigurationsNOTE: The BIOS can be overwritten/upgraded using the FLASH utility (AWDFLASH.EXE).ProcessorItem

24 Veriton 3500/5500/7500This section has two table lists, system memory specification and the possible combinations of memory module. *X, Y, Z: 0~2GB

Chapter 1 25 NOTE: S88M/ GL for Veriton 3500/ 5500/ 7500 doesn’t have AGP VGA slot.Cache MemoryItem SpecificationFirst-Level Cache ConfigurationsCache

26 Veriton 3500/5500/7500Audio InterfaceItem SpecificationAudio controller Embedded in Intel 82801DB ICH 4Audio controller resident bus AC’97 linkAudi

Chapter 1 27MTBF (Mean Time Between Failure) 30,000Floppy disk drive controller Embedded in SMSC LPC47M192Floppy disk drive controller resident bus LP

28 Veriton 3500/5500/7500Power Requirement +5V +12VVoltage tolerance +/-5% +/-5%Standby (Sleep) 150mA 2mAAvtiv 500mA 1.2ACD-R/W InterfaceItem Specific

Chapter 1 29Optional serial port I/O address(via BIOS Setup)2F8-2FF3F8-3FFOptional serial port IRQ(via BIOS Setup)4, 3Modem Item SpecificationFax mode

30 Veriton 3500/5500/7500Note : UPPER LIMIT means the maximum size of installed memory. The Main Memory Maximum size are 768M Bytes.

IVConventionsThe following conventions are used in this manual:Screen messages Denotes actual messages that appear on screen.NOTEGives bits and pieces

Chapter 1 31NOTE: N - Not be used.I/O Address MapHex Range Devices000-00F020-021040-043060-060061-061070-071081-08F0A0-0A10C0-0DF0F0-0FF170-1771F0-1F7

32 Veriton 3500/5500/7500NOTE: N - Not to be used.DRQx Assignment MapDRQx System Devices Add-On-Card DevicesDRQ0 N (Notes) Reserved DRQ1 N Reserved DR

Chapter 1 33(This is 145W power supply)! This “4A” includes the outlet supply current: 2A! Measure at line input 90 VRMS and maximum load condition.NO

34 Veriton 3500/5500/7500Power Management FunctionsDevice Standby Mode! Independent power management timer for hard disk drive devices (0-15 minutes,

Chapter 2 36Most systems are already configured by the manufacturer or the dealer. There is no need to run Setup when starting the computer unless you

37 Veriton 3500/5500/7500Entering SetupTo enter Setup, press the key cccc during the POST (Power-on self-test). NOTE: You must press cccc simultaneous

Chapter 2 38Product InformationThe screen below appears if you select Product Information from the main menu: The Product Information menu contains ge

39 Veriton 3500/5500/7500Standard CMOS FeaturesSelect “Standard CMOS Features” from the main menu to configure the drives installed in your system.The

Chapter 2 40Drive A Allows you to configure your floppy drive A.1.44 MB, 3.5-inchNone360 KB, 5.25-inch1.2 MB, 5.25-inch720 KB, 3.5-inch2.88 MB, 3.5-in

41 Veriton 3500/5500/7500IDE Primary Master/Slave and IDE Secondary Master/Slave SetupThe following screen appears if you select any of the IDE drive

VPrefaceBefore using this information and the product it supports, please read the following general information.1.This Service Guide provides you wit

Chapter 2 42Advanced BIOS FeaturesThe following screen shows the Advanced BIOS Features.The following table describes each Advanced BIOS Features para

43 Veriton 3500/5500/7500Boot Other Device This parameter allows you to specify the systeboot up search sequence.EnabledDisabledSecurity Option The Se

Chapter 2 44Advanced Chipset FeaturesThe following screen shows the Advanced Chipset Features.The following table describes each Advanced Chipset Feat

45 Veriton 3500/5500/7500Integrated PeripheralsThe following table describes each Integrated Peripherals parameter. Settings in boldface are the defau

Chapter 2 46IDE Primary Master PIOIDE Primary Slave PIOIDE Secondary Master PIOIDE Secondary Slave PIOSetting these items to Auto activates the HDD sp

47 Veriton 3500/5500/7500Onboard Serial Port 2 This item allows you to assign an address and interrupt for the board serial port.2F8/ IRQ3Auto3F8/ IRQ

Chapter 2 48Power Management SetupThe Power Management menu lets you configure the system power-management feature. It works only in APM mode.IMPORTAN

49 Veriton 3500/5500/7500The following table describes the parameters found in this menu.Parameter Description OptionsRun VGABIOS if S3 Resume Auto:BI

Chapter 2 50NOTE: In ACPI mode: Valid-S5 and S4. In APM mode: Valid- shutdownResume by Alarm(Function Enabled in ACPI and APM Mode)Use this option to

51 Veriton 3500/5500/7500PnP/PCI ConfigurationsThe table below describes each PnP/PCI configuration parameter. Settings in boldface are the default an

VI

Chapter 2 52PCI/VGA Palette Snoop This parameter permits you to use the palette snooping feature if you installed more than one VGA card in the syste

53 Veriton 3500/5500/7500PC Health StatusParameter Description OptionsCPU Shutdown Temperature(Function Enabled in ACPI Mode)When the temperature of t

Chapter 2 54System Warning Temperature(Function Enabled in ACPI ModeWhen the temperature of the system reaches the default value, the system will give

55 Veriton 3500/5500/7500Frequency ControlThe following table describes the parameters found in this menu. Parameter DescriptionProcessor Indicates t

Chapter 2 56System SecurityThe Setup program has a number of security features to prevent unauthorized access to the system and its data. Supervisor P

57 Veriton 3500/5500/7500

Chapter 2 58User PasswordIMPORTANT:To show the “Set User Password”:1.Choose “Set Superviser Password” and press eeee.2.Type the password and then pre

59 Veriton 3500/5500/7500Bypassing the PasswordIf you forgot your password, you can bypass the password security feature thru hardware configuration.

Chapter 2 60Load Default SettingsYou need to reload the BIOS default settings every time you make changes to your system hardware configuration (such

61 Veriton 3500/5500/7500Exiting SetupTo exit the BIOS utility, simply press ^^^^. The following dialog box appears: Select Yes to exit Setup. Select

VIITable of ContentsChapter 1 System Specifications 1Overview . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Chapter 2 62Advanced Options NOTE: The Advanced Options menu is available only when you press aaaa+oooo in the main menu.The “Advanced Options” me

63 Veriton 3500/5500/7500Advanced BIOS FeaturesSelecting “Advanced BIOS Features” from the Advanced Options menu displays the following screen:

Chapter 2 64Advanced Chipset Features Selecting “Advanced BIOS Features” from the Advanced Options menu displays the following screen.The following t

65 Veriton 3500/5500/7500Integrated Peripherals.Parameter Description OptionDRAM Timing Selectable CAS Latency Time Active to Precharge

Chapter 2 66The following table describes the parameters found in the sub-menu. Settings in boldface are the default and suggested settings.Power Mana

67 Veriton 3500/5500/7500The following table describes the parameters found in the sub-menu. Settings in boldface are the default and suggested settin

Chapter 2 68NOTE: These are global timer events.The following table describes the parameters found in the sub-menu.Frequency ControlSelecting “ Freque

69 Veriton 3500/5500/7500The following table describes the parameters found in the sub-menu.Parameter Description OptionCPU Clock Ratio Core Clock Fre

Chapter 3 70This chapter contains step-by-step procedures on how to disassemble the Veriton 3500/ 5500/ 7500 and the Veriton 3500G/ 5500G/ 7500G deskt

71 Veriton 3500/5500/7500General InformationBefore You BeginBefore proceeding with the disassembly procedure, make sure that you do the following:1.Tu

VIIITable of ContentsRemoving the Intrusion Alarm Cable Module . . . . . . . . . . . . . . . . . . . . . . 77Removing the DIMM . . . . . . . . . .

Chapter 3 72Veriton 3500/ 3500G Disassembly Flow ChartNOTE: There is no AGP VGA slot for Veriton 3500.Housing CoverFront BezelRTC BatteryMain UnitFron

73 Veriton 3500/5500/7500Disassembling the Veriton 3500/ 3500GOpening the HousingThis section tells you how to open the housing cover when you need to

Chapter 3 74Removing the Front Panel1.See “Removing the Housing Cover” on page 732.Remove the four screws as shown here.3.Detach the front bezel from

75 Veriton 3500/5500/7500Removing the LAN Card1.See “Removing the Housing Cover” on page 732.Remove the screw as shown below and then remove the modem

Chapter 3 765.Disconnect the intrusion alarm cable from the main board and then pull the FDD and DVD frame from the lower case.6.Remove the floppy dis

77 Veriton 3500/5500/7500Removing the Intrusion Alarm Cable Module1.See “Removing the Housing Cover” on page 732.See “Removing the FDD and DVD Frame”

Chapter 3 78Removing and Installing the RTC Battery1.See “Removing the Housing Cover” on page 732.Press the latch to release the RTC battery, lift up

79 Veriton 3500/5500/7500Removing the USB/ Audio Board1.See “Removing the Housing Cover” on page 732.See “Removing the FDD and DVD Frame” on page 753.

Chapter 3 80Removing the Hard Disk Drive1.See “Removing the Housing Cover” on page 732.See “Removing the FDD and DVD Frame” on page 753.Disconnect the

81 Veriton 3500/5500/7500Removing the LED Activity Indicators1.See “Removing the Housing Cover” on page 73.2.See “Removing the FDD and DVD Frame” on p

IXTable of ContentsChapter 4 Troubleshooting 110Power-On Self-Test (POST) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Chapter 3 82Removing the Power Supply1.See “Removing the Housing Cover” on page 73.2.Disconnect the FDD power connector from the FDD drive and the DVD

83 Veriton 3500/5500/75004.Remove the CPU fan sink from the main board and then put the levers back to their original positions.WARNING:The heatsink b

Chapter 3 84Removing the System Main board1.See “Removing the Housing Cover” on page 732.See “Removing the FDD and DVD Frame” on page 753.See “Removin

85 Veriton 3500/5500/7500Veriton 5500/ 5500G Disassembly Procedure FlowchartNOTE: There is no AGP slot for Veriton 5500.Housing CoverMain UnitDummy Li

Chapter 3 86Disassembling the Veriton 5500/ 5500GOpen the Housing CoverThis section tells you how to open the housing cover when you need to install a

87 Veriton 3500/5500/7500Removing the Empty Cover1.See “Removing the Housing Cover” on page 862.See “Removing the Front Panel” on page 863.Release the

Chapter 3 88Removing the AGP VGA Card1.See “Removing the Housing Cover” on page 862.Remove the screw on the bracket of the AGP card. Set the screw as

89 Veriton 3500/5500/7500.5.Disconnect the USB cable and memory stick cable from the USB/ Audio board consecutively.Removing a DIMM1.See “Removing th

Chapter 3 90Removing the CPU Fan Sink1.See “Removing the Housing Cover” on page 862.See “Removing a Dummy Link Bar” on page 873.Detach the fan/heatsin

91 Veriton 3500/5500/7500Removing and Installing the Processor1.See “Removing the Housing Cover” on page 862.See “Removing a Dummy Link Bar” on page 8